瓦斯發電機組起動時，不能無冷卻液或加入沸水起動、不允許不按規定供油、不能長時間使用電熱塞、也不能長時間連續起動等等。那么還有怎樣的不良做法呢？

When starting the gas generator unit, it is not allowed to start without coolant or boiling water, not allowed to supply oil as required, not allowed to use the glow plug for a long time, and not allowed to start continuously for a long time. So what are the bad practices?

1、無冷卻液或加入沸水起動：瓦斯發電機起動后再加冷卻液，會使熾熱的缸套、缸蓋等重要部件因驟然遇冷而引起炸裂或變形;向冰冷的機體內驟加100℃的開水，同樣會激裂缸蓋和機體，應待冷卻液溫度降至60-70℃時再加入。

1. Starting without coolant or adding boiling water: adding coolant after starting the gas generator will cause cracking or deformation of hot cylinder liners, cylinder heads and other important parts due to sudden cooling; Add 100 ℃ boiled water to the cold engine block, which will also crack the cylinder head and engine block. Add the water after the coolant temperature drops to 60-70 ℃.

2、不按規定供油：瓦斯發電機不應在起動時將減壓手柄放到“工作”位置后再供油，而應該在起動前就將油門手柄放到供油的位置上。不按該規定操作的害處是：浪費燃油;多余的瓦斯會沖刷缸壁，使活塞、活塞環與氣缸套之間潤滑惡化而加劇磨損;余油流入油底殼會稀釋機油而降低潤滑效果;氣缸中過多的瓦斯燃燒不完全會形成積炭。

2. Oil supply not in accordance with regulations: gas generator should not put the pressure relief handle to the "working" position before oil supply, but should put the throttle handle to the oil supply position before starting. The disadvantages of not following the regulations are: waste of fuel; Excess gas will wash the cylinder wall, making the lubrication between the piston, piston ring and cylinder liner worsen and aggravate the wear; The residual oil flowing into the oil pan will dilute the oil and reduce the lubrication effect; Too much gas in the cylinder will not completely burn and form carbon deposits.

3、拉車起動：瓦斯發電機在冷機時機油粘度很大，在這種情況下拉車起動，會加劇各運動件之間的磨損，從而降低機車的使用壽命。

3. Pulling start: the oil viscosity of the gas generator is very high when it is cold. In this case, the pulling start will aggravate the wear between moving parts, thus reducing the service life of the locomotive.

4、不近期換用機油、燃油：在天氣寒冷的季節，如果不及時改換粘度低的機油和燃油，瓦斯發電機就很難起動。

4. Change of engine oil and fuel oil in the near future: In cold weather, if the engine oil and fuel oil with low viscosity are not changed in time, the gas generator will be difficult to start.

5、用明火烘烤油底殼和在進氣管處引火起動：為防止發生火災，應用文火、煤火在一定距離外烘烤瓦斯發電機的油底殼，同時慢慢轉動曲軸，讓機油均勻受熱，使各部位都得到潤滑。若在瓦斯發電機進氣管處引火起動，會使物質燃燒產生的灰燼及硬雜物吸進氣缸，造成進、排氣門關閉不嚴而加快氣缸的磨損。

5. Bake the oil pan with an open fire and start it with a fire at the intake pipe: in order to prevent a fire, use a soft fire or coal fire to bake the oil pan of the gas generator at a certain distance, while slowly turning the crankshaft to evenly heat the engine oil and lubricate all parts. If the gas generator is ignited and started at the air inlet pipe, the ash and hard sundries generated by material combustion will be sucked into the cylinder, resulting in the untight closing of the air inlet and exhaust valves and accelerating the wear of the cylinder.

瓦斯發電機上的起動機是在低電壓、大電流的情況下工作的，長時間使用會損壞蓄電池。其連續工作的時間不得超過10s;一次起動不行，應隔15s再起動。更多相關內容就來我們網站http://m.hdlelisa.com咨詢吧！

The starter on the gas generator works under the condition of low voltage and large current, and the battery will be damaged if it is used for a long time. The continuous working time shall not exceed 10s; If one start fails, restart after 15s. More relevant content will come to our website http://m.hdlelisa.com Consult!